Bulletin #4085, Let’s Preserve: Tomatoes

Print Friendly, PDF & Email

Bulletin #4085, Let’s Preserve: Tomatoes (PDF)

Developed by Penn State Cooperative Extension with special project funds from Extension Service, U.S. Department of Agriculture.

For information about UMaine Extension programs and resources, visit extension.umaine.edu.
Find more of our publications and books at extension.umaine.edu/publications/.


tomatoesTable of Contents


Recommended Varieties

Campbell 1327, Heinz 1350, Heinz 1370, Pik-Red, Supersonic, and late-season Ramapo are good choices for making juice, crushed, and whole tomato products. Italian and pear-type varieties are good for making sauce, ketchup, and purees.

Quality

Select only disease-free, preferably vine-ripened, firm fruit for canning. Do not can tomatoes from dead or frost-killed vines. Green tomatoes are more acidic than ripened fruit and can be canned safely with any of the following recommendations.

Quantity

Table 1. Quantities of Fresh Tomatoes Needed for Tomato Products

Product Pounds of fresh tomatoes needed for
One quart One pint A canner load
of 7 quarts
A canner load
of 9 pints
Juice 3-1/4 23 14
Juice vegetable blend 3 1-1/2 22 14
Whole, halved, crushed 3 1-1/2 21 13
Tomatoes & okra or zucchini 12 7
Chili salsa 7
Standard sauce-thin 5 2-1/2 35 21
Standard sauce-thick 6-1/2 3 46 28
Spaghetti sauce 6-1/3 3-1/3 44 30
Hot barbecue sauce 6-1/3 3-1/3 44 30
Regular ketchup 7-1/2 4 53 36
Western ketchup 7-1/2 4 53 36
Blender ketchup 5 2-2/3 35 24

Acidification

To ensure safe acidity in whole, crushed, or juiced tomatoes, add 2 tablespoons of bottled lemon juice or 1/2 teaspoon of citric acid per quart of tomatoes. For pints, use 1 tablespoon of bottled lemon juice or 1/4 teaspoon citric acid. Sugar to taste may be added to offset acid taste.

Freezing

Freezing of tomato products is an acceptable practice but frozen whole tomatoes can become limp after thawing. Quality of canned products is very acceptable, and overall costs of preserving tomatoes favor canning.

How To Freeze Tomatoes (YouTube video)

Canning Procedure

Wash jars. Prepare lids according to manufacturer’s instructions. Fill hot tomato products in jars. Wipe sealing edge of jars with a clean, damp paper towel. Add lids and tighten screw bands. Process in a boiling water or a pressure container.

To process in a boiling water canner, fill canner halfway with water and preheat to 180°F for hot packs or 140°F for raw packs. Load sealed jars onto the canner rack and lower with handles; or load one jar at a time with a jar lifter onto rack in canner. Add water, if needed, to a level of 1 inch above jars and add canner cover. When water boils vigorously, lower heat to maintain a gentle boil and process jars for the time given in Table 2.

Process Times

Table 2. Recommended Processing Times in Boiling Water Canner

Product Pack Minutes of processing time at altitudes of:
Jar size 0-1000 ft. 1001-3000 ft 3001-6000 ft Above 6000 ft.
Tomato juice, tomato vegetable juice blend, and crushed tomatoes Hot Pints
Quarts
35
45
40
50
45
55
50
60
Whole or halved tomatoes packed in water Hot or raw Pints
Quarts
40
45
45
50
50
55
55
60
Whole or halved tomatoes packed in juice or without added liquid Hot or raw Pints or Quarts 85 90 95 100
Chili salsa Hot Pints 15 20 20 25
Standard tomato sauces (thin or thick) Hot Pints
Quarts
35
40
40
45
45
50
50
55
All tomato ketchups Hot Pints 15 20 20 25

To process in a pressure canner, place jar rack, 2 inches of water, and sealed jars in canner. Fasten lid, and heat canner on high setting. After steam exhausts 10 minutes, add weighted gauge or close petcock to pressurize the canner. Start timing the recommended process when the desired pressure is reached. Regulate heat to maintain a uniform pressure, and process the product for the time given in Table 3.

Table 3. Canner Processing Times and Pressures at Designated Altitudes
Product Style Pack Jar size Process time (min) Dial Gauge
Weighted Gauge
Canner Gauge pressure at altitudes of
0-2000 ft. (lbs.) 2001-4000
ft. (lbs.)
4001-6000 ft. (lbs.) 6001-8000 ft. (lbs.) 0-1000 ft. (lbs.) Above 1000 ft. (lbs.)
Tomato juice, tomato vegetable juice blend, and crushed tomatoes Hot Pint or Quart 15 11 12 13 14 10 15
Whole or halved tomatoes packed in water Hot or Raw Pint or Quart 10 11 12 13 14 10 15
Whole or halved tomatoes packed in juice or without added liquid Hot or Raw Pint or Quart 25 11 12 13 14 10 15
Tomatoes and okra or zucchini Hot Pint
Quart
30
35
11
11
12
12
13
13
14
14
10
10
15
15
Standard tomato sauces (thin or thick) Hot Pint or Quart 15 11 12 13 14 10 15
Spaghetti sauce with meat Hot Pint
Quart
60
70
11
11
12
12
13
13
14
14
10
10
15
15
Hot barbecue sauce Hot Pint
Quart
20
25
11
11
12
12
13
13
14
14
10
10
15
15

When processing is complete, remove canner from heat. Air-cool canner until it is fully depressurized. Slowly remove weighted gauge or open petcock, wait 2 more minutes, and unfasten and carefully remove canner lid.

After processing is completed, remove jars from canner with a jar lifter and place on a towel or rack. Do not retighten screw bands. Air-cool jars 12 to 24 hours. Remove screw bands and check lid seals. If the center of the lid is indented, wash, dry, label, and store jars in a clean, cool, dark place. If the lid is unsealed, examine and replace jar if defective, use new lids, and reprocess as before. Wash screw bands and store separately. Tomato products are best if eaten within 1 year and safe as long as lids remain vacuum sealed.


Tomato Juice

Quantity. See Table 1 for guidelines.

Procedure. Wash, remove stems, and trim off bruised or discolored portions. To prevent juice from separating, quickly cut about a pound of fruit into quarters and put directly into saucepan. Heat immediately to boiling while crushing. Continue to slowly add and crush freshly cut tomato quarters to the boiling mixture. Make sure the mixture boils constantly and vigorously while you add the remaining tomatoes. Simmer 5 minutes after you add all the pieces.

If you are not concerned about juice separation, simply slice or quarter tomatoes into a large saucepan. Crush, heat, and simmer for 5 minutes before juicing. Press both types of heated juice through a sieve or food mill to remove skins and seeds. Add bottled lemon juice or citric acid to jars; see acidification instructions. Reheat juice to boiling. Add 1 teaspoon salt per quart, if desired. Fill jars with hot tomato juice, leaving 1/2-inch headspace. Adjust lids and process jars as described in Table 2 or Table 3.


Tomato and Vegetable Juice Blend

Quantity. See Table 1 for guidelines.

Procedure. Crush and simmer tomatoes same as for making tomato juice. To make 7 quarts, use 22 pounds of tomatoes, and add no more than 3 cups of any combination of finely chopped celery, onions, carrots, and peppers for each 22 pounds of tomatoes. Simmer mixture 20 minutes. Press hot, cooked tomatoes and vegetables through a sieve or food mill to remove skins and seeds. Add bottled lemon juice or citric acid to jars; see acidification directions. Add 1 teaspoon salt per quart, if desired. Reheat tomato-vegetable juice blend to boiling and fill immediately into jars, leaving 1/2-inch headspace. Adjust lids and process jars as described in Table 2 or Table 3.


Whole, Halved or Crushed Tomatoes

Quantity. See Table 1 for guidelines.

Procedure for whole or halved tomatoes packed in water. Wash tomatoes and dip in boiling water for 30 to 60 seconds or until skins split. Then dip in cold water, slip off skins, and remove cores. Leave whole or halve. Add bottled lemon juice or citric acid to jars; see acidification directions. Add 1 teaspoon of salt per quart if desired, and add enough hot cooking water to cover tomatoes, leaving 1/2-inch headspace. Raw pack — Fill jars with raw peeled tomatoes, add 1 teaspoon salt per quart, and add hot water to cover tomatoes, leaving 1/2-inch headspace. Adjust lids and process jars as described in Table 2 or Table 3.

Procedure for whole or halved tomatoes packed with tomato juice, or filled without added liquids. Prepare, peel, and acidify tomatoes as described for tomatoes packed in water. Fill jars with raw-packed tomatoes, leaving 1/2-inch headspace; or bring tomatoes to a boil in water or tomato juice and boil gently 5 minutes. Add 1 teaspoon of salt per quart, if desired. Fill jars with hot tomatoes, allowing 1/2-inch headspace. Cover tomatoes with hot juice or press tomatoes until spaces fill with juice, leaving 1/2-inch headspace. Adjust lids and process jars as described in Table 2 or Table 3.

Procedure for crushed tomatoes. Wash tomatoes and dip in boiling water for 30 to 60 seconds or until skins split. Then, dip in cold water, slip off skins, and remove cores. Trim off any bruised or discolored portions and quarter. Heat quarters quickly in a large pot, stirring to prevent burning. Boil gently 5 minutes. Add bottled lemon juice or citric acid to jars; see acidification directions. Add 1 teaspoon of salt per quart if desired. Fill jars immediately with quartered hot tomatoes, leaving 1/2-inch headspace. Adjust lids and process jars as described in Table 2 or Table 3.


Tomatoes and Okra or Tomatoes and Zucchini

Quantity. See Table 1 for guidelines.

Procedure. Wash tomatoes and 4 pounds of okra or zucchini if making a 7 quart batch and 2.5 pounds if you are making a 9 pint batch. These ratios have been tested for safety and altering them is not recommended. Dip tomatoes in boiling water for 30 to 60 seconds or until skins split. Then dip in cold water, slip off skins, remove cores, and quarter. Trim stems from okra and slice into 1-inch pieces or leave whole. Slice or cube zucchini if used. Bring tomatoes to a boil and simmer 10 minutes. Add okra and zucchini and boil gently 5 minutes. Add 1 teaspoon salt to each quart, if desired. Fill jars with mixture, leaving 1-inch headspace. Adjust lids and process jars as described in Table 3.

Variation: You may add four or five pearl onions or two onion slices to each jar.


Chili Salsa (Hot Pepper-Tomato Dip)

Ingredients:
7 lbs. tomatoes, chopped
1-2 lbs. chili peppers, chopped
1 lb. onion, chopped
1 cup vinegar or 1/2 cup bottled lemon juice
1 tbsp. salt
1/2 tsp. pepper

Yield: about 9 pints

Procedure: Prepare hot peppers and tomatoes as described for use in making hot barbecue sauce. Combine all ingredients in a large kettle. Bring to a boil and simmer ten minutes. Fill jars, leaving 1/2-inch headspace. Adjust lids and process jars as described in Table 2.


Standard Tomato Sauce

Procedure: Wash, remove stems, and trim off bruised or discolored portions. To prevent sauce from separating, quickly cut about 1 pound of tomatoes into quarters and put directly into saucepan. Heat immediately to boiling while crushing. Continue to slowly add and crush freshly cut tomato quarters to the boiling mixture. Make sure the mixture boils constantly and vigorously while you add remaining tomatoes. Simmer 5 minutes after all tomatoes are added. If you are not concerned about sauce separating, simply slice or quarter tomatoes into a large saucepan. Crush, heat, and simmer for 5 minutes before pressing. Press either type of heated juice through a sieve or food mill to remove skins and seeds. Heat juice again to boiling. Simmer in a large-diameter saucepan until sauce reaches desired consistency. Boil until volume is reduced by about one-third for thin sauce, or by one-half for thick sauce. Add bottled lemon juice or citric acid to jars; see acidification directions. Fill jars, leaving 1/4-inch headspace. Adjust lids and process jars as described in Table 2 or Table 3.


Spaghetti Sauce without Meat

Ingredients:
30 lbs. tomatoes
1 cup onions, chopped
5 cloves garlic, minced
1 cup celery or green pepper, chopped
1 lb. fresh mushrooms, sliced (optional)
4-1/2 tsp. salt
2 tbsp. oregano
4 tbsp. parsley, minced
2 tsp. black pepper
1/4 cup brown sugar
1/4 cup vegetable oil

Yield: about 9 pints

Procedure: Do not increase the proportion of onions, peppers, or mushrooms. Wash tomatoes and dip in boiling water for 30 to 60 seconds or until skins split. Dip in cold water and slip off skins. Remove cores and quarter tomatoes. Boil 20 minutes, uncovered, in large saucepan. Squeeze out juice with a food mill or sieve. Sauté onions, garlic, celery or peppers, and mushrooms (if desired) in vegetable oil until tender. Combine sautéed vegetables and tomatoes and add remainder of spices, salt, and sugar. Bring to a boil. Simmer, uncovered, until thick enough for serving. At this time the initial volume will have been reduced by nearly one-half. Stir frequently to avoid burning. Fill jars, leaving 1-inch headspace. Adjust lids and process jars as described in Table 3.

Procedure for making sauce with meat: Sauté 2-1/2 pounds of ground beef or sausage until brown. Using the recipe for making sauce without meat, add the quantities specified for garlic, onion, celery or green pepper, and mushrooms. Cook until vegetables are tender. Combine sautéed meat and vegetables with the tomato juice. Then follow the directions above for making sauce without meat.


Hot Barbecue Sauce

Ingredients:
2-1/2 to 3 lbs. chili peppers
30 lbs. tomatoes
3 cups onions, chopped
1 tbsp. salt
1 tbsp. oregano
1/2 cup vinegar (5%)

Yield: about 9 pints

Procedure: Caution – Wear rubber gloves while handling chilis or wash hands thoroughly with soap and water before touching your face. Wash and dry chilis. Slit the sides of peppers and peel them using one of the following methods:

Oven or broiler method: Place chilis in oven (400o F) or broiler 6-8 minutes until skins blister.

Range top method: Cover hot burner, either gas or electric, with heavy wire mesh. Place chilis on burner for several minutes until skins blister.

Allow peppers to cool. Place in a pan and cover with a damp cloth. This will make peeling the peppers easier. After several minutes, peel each pepper. Cool and slip off skins. Discard seeds and chop peppers. If desired, leave skins on and grind or coarsely chop peppers. Wash tomatoes and dip in boiling water for 30 to 60 seconds or until skins split. Dip in cold water, slip off skins, and remove cores. Coarsely chop tomatoes and combine chopped peppers and remaining ingredients in a large kettle. Bring to a boil. Simmer, uncovered, 2 to 3 hours or until the initial volume is reduced by one-third to one-half. Stir frequently to avoid burning. Fill jars, leaving 1-inch headspace. Adjust lids and process as described in Table 3.


Standard Tomato Ketchup

Ingredients:
24 lbs. ripe tomatoes
3 cups onions, chopped
3/4 tsp. ground red pepper (cayenne)
3 cups cider vinegar (5%)
4 tsp. whole cloves
3 sticks cinnamon, crushed
1-1/2 tsp. whole allspice
3 tbsp. celery seeds
1-1/2 cups sugar
1/4 cup salt

Yield: 6 to 7 pints

Procedure: Wash tomatoes. Dip in boiling water for 30 to 60 seconds or until skins split. Dip in cold water. Slip off skins and remove cores. Quarter tomatoes into 4-gallon stock pot or a large kettle. Add onions and red peppers. Bring to a boil and simmer uncovered for 20 minutes. Combine spices in a spice bag and add vinegar in a 2-quart saucepan. Bring to boil. Cover. Turn off heat and let stand 20 minutes. Then, remove spice bag and combine vinegar and tomato mixture. Boil about 30 minutes. Put boiled mixture through a food mill or sieve. Return to pot. Add sugar and salt, boil gently, and stir frequently until volume is reduced by one-half or until mixture rounds up on spoon without separation. Fill pint jars, leaving 1/8-inch headspace. Adjust lids and process jars as described in Table 2.


Country Western Ketchup

Ingredients:
24 lbs. ripe tomatoes
5 chili peppers, sliced and seeded
1/4 cup salt
2-2/3 cups vinegar (5%)
1-1/4 cups sugar
1/2 tsp. ground red pepper (cayenne)
4 tsp. paprika
4 tsp. whole allspice
4 tsp. dry mustard
1 tbsp. whole peppercorns
1 tsp. mustard seed
1 tbsp. bay leaves

Yield: 6 to 7 pints

Procedure: Follow directions for standard tomato ketchup.


Blender Ketchup

Uses electric blender, eliminating need for pressing or sieving.

Ingredients:
24 lbs. ripe tomatoes
2 lbs. onions
1 lb. sweet red peppers
1 lb. sweet green peppers
9 cups vinegar (5%)
9 cups sugar
1/4 cup canning or pickling salt
3 tbsp. dry mustard
1-1/2 tbsp. ground red pepper
1-1/2 tsp. whole allspice
1-1/2 tbsp. whole cloves
3 three-inch sticks of cinnamon

Yield: 9 pints

Procedure: Wash tomatoes and dip in boiling water for 30 to 60 seconds or until skins split. Then dip in cold water, slip off skins, core, and quarter. Remove seeds from peppers and slice into strips. Peel and quarter onions. Blend tomatoes, peppers, and onions at high speed for 5 seconds in electric blender. Pour into a 3- to 4-gallon stock pot or large kettle and heat. Boil gently 60 minutes, stirring frequently. Add vinegar, sugar, salt, and a spice bag containing dry mustard, red pepper, and other spices. Continue boiling and stirring until volume is reduced one-half and ketchup rounds up on a spoon with no separation of liquid and solids. Remove spice bag and fill jars, leaving 1/8-inch headspace. Adjust lids and process jars as described in Table 2.

Nutritional Information: Average content of a 1/2 cup serving (4 to 4.4 oz.) of Tomato Products

Raw Canned
Tomato,
unpeeled
Tomato,
peeled
Tomato
juice
Whole or
crushed,
salted
Whole or
crushed,
unsalted
Calories 10 10 23 25 25
Carbohydrates, g 2 2 5 5 5
Fats, g 0.1 0.1 0.1 0.3 0.3
Protein, g 0.5 0.5 1.1 1.2 1.2
Sodium, mg 1.5 1.5 243 156 7
Riboflavin * 2 2 2 2
Thiamine * 2 4 4 4
Vitamin A * 8 8 20 20 20
Vitamin C * 15 15 30 30 30

* Expressly as percentage of U.S. Recommended Daily Allowance (US RDA). Tomatoes are an insignificant source of other vitamins.


Information in this publication is provided purely for educational purposes. No responsibility is assumed for any problems associated with the use of products or services mentioned. No endorsement of products or companies is intended, nor is criticism of unnamed products or companies implied.

© 2000, 2011

Call 800.287.0274 (in Maine), or 207.581.3188, for information on publications and program offerings from University of Maine Cooperative Extension, or visit extension.umaine.edu.

The University of Maine is an EEO/AA employer, and does not discriminate on the grounds of race, color, religion, sex, sexual orientation, transgender status, gender expression, national origin, citizenship status, age, disability, genetic information or veteran’s status in employment, education, and all other programs and activities. The following person has been designated to handle inquiries regarding non-discrimination policies: Sarah E. Harebo, Director of Equal Opportunity, 101 North Stevens Hall, University of Maine, Orono, ME 04469-5754, 207.581.1226, TTY 711 (Maine Relay System).